Comparison of the antioxidant effects of carnosic acid and synthetic antioxidants on tara seed oil
© The Author(s) 2018
Received: 30 August 2017
Accepted: 12 February 2018
Published: 4 April 2018
In the present study, tara seed oil was obtained by supercritical fluid extraction and used to investigate the antioxidant strength of carnosic acid (CA) compared with conventional synthetic antioxidants.
The antioxidants were added to the tara seed oil at 0.2 mg of antioxidant per gram of oil. The samples were then submitted to at 60 °C 15 days for an accelerated oxidation process, with samples taken regularly for analysis. After oxidation, the samples were analyzed to determine the peroxide value, thiobarbituric acid reactive substances, conjugated diene content, and free fatty acid content. CA was investigated at three purity levels (CA20, CA60, CA99), and compared with three synthetic antioxidants (butylatedhydroxyanisole, butylatedhydroxytoluene, and tert-butylhydroquinone).
As an important plant tannis, tara (Caesalpiniaspinosa) is a kind of precious tree which represents significantly economic benefit, ecological benefit and social benefit. Besides, oil extracted from tara seeds has high content of unsaturated fatty acids. In recent years, it has received extensive attention among researchers . The eight major fatty acids in tara seed oil are palmitic acid, palmitoleic acid, stearic acid, oleic acid, linoleic acid, arachidonic acid, linolenic acid, and behenic acid. The dominant unsaturated fatty acids are linoleic acid, oleic acid, behenic acid, and linolenic acid with contents of 65.36%, 13.33%, 2.30% and 0.99%, respectively [2, 3]. Its comprehensive exploitation and utilization is relatively low and correlation studiesand reports are rarely seen, so tara can be studied and developed deeply as an energy plant.
To date, some research has been conducted on tara seed oil and its applications, but this area of research is still in its infancy. The unsaturated double bonds in tara seed oil are sensitive, the unsaturated double bonds present in the fatty acids of tara oil are sensitive to oxidation, which may affect the overall quality of the oil [4, 5]. Exposure of tara seed oil to high temperatures and light can result in oxidation and increase the peroxide value (PV), which makes the oil unpalatable [6, 7]. The PV is an indicator of the peroxide content and degree of oxidization of an oil. It can be used to determine the degree of lipid oxidation and deterioration, and is mainly used to measure the formation of lipid oxidation products in initial stages of oxidation. It provides a measure of the degree of oil rancidity, and a higher PV is generally indicative of a higher the degree of rancidity. High temperatures and exposure to light are known to promote peroxide formation [8, 9]. The oil is then not beneficial for human consumption because of its rancidity, and increased content of free radicals that are produced by oxidation [10–13]. Tara seed oil with a higher content of unsaturated fatty acids, especially polyunsaturated fatty acids, is more susceptible to oxidation than oil with a lower content of unsaturated fatty acids . Oxidation of lipids in oils can produce rancid odors, unpleasant flavors, and discoloration, and also decrease the nutritional quality and safety because the resulting degradation products can have harmful effects on human health [15, 16].
Oxidation can occur during oil storage and transportation, and the addition of appropriate antioxidants can inhibit free radical generation and stop rancidification . Currently, the most commonly used type of antioxidants are synthetic ones such as (BHA), (BHT), and (TBHQ) . Studies have shown that these synthetic antioxidants can have differing degrees of toxicity in humans, and can affect the liver, spleen, and lungs [19–21].
The antioxidant strength of a compound can be evaluated by investigating its effect on a number of oxidation indicators, including PV, thiobarbituric acid reactive substances (TBARS), conjugated diene (CD) content, and free fatty acid (FFA) content. In the present study, the antioxidant abilities of carnosic acid (CA) and the synthetic antioxidants BHA, BHT, and TBHQ in tara seed oil were compared. Carnosic acid is a phenolic (catecholic) diterpene, endowed with antioxidative and antimicrobial properties. These results provide a theoretical basis for application of CA to preservation of oils during storage and transportation.
Materials and methods
Refined, bleached, and deodorized tara seed oil was obtained by Supercritical Fluid Extraction from tara powder (60 mesh) prepared from fresh tara seeds (Wonderful variety) that were collected from Yunnan Province, China in September, 2014. The α-tocopherolactalso also as an antioxidant, which content was very low (< 4.3 mg kg−1), and the oil contained no synthetic antioxidants, all reagents and solvents were either of HPLC or analytical grade. BHA, BHT, TBHQ, Folin–Ciocalteu reagent, gallic acid standard, catechin standard, and free radicals, and CA were purchased from Sigma-Aldrich Co. (St. Louis, MO, USA).
Preparation of oil
Fresh tara seeds were dried in an oven at 45 °C to constant mass, and then ground into powder (60 mesh). Oil was extracted from the powder using supercritical fluid extraction under the following conditions: extraction time 120 min, extraction temperature 45 °C, and extraction pressure 35 MPa, CO2 was the only fluid used.
110 mL of tara oil were placed in 125-mL brown-colored reagent bottles with narrow necks. The bottles were divided into seven groups, with each group containing three bottles for replication of the experiments. One group of bottles was designated as the blank controls, and CA of different purity (CA20, CA60, and CA99) was added to the first group experiment with three differents bottles at 0.2 mg of CA per gram of oil. The other six groups experiments were designated as synthetic antioxidant groups, and BHA, BHT, TBHQ were added at 0.2 mg of antioxidant per gram of oil [22, 23]. Each bottle was placed on a magnetic stirrer for 30 min to thoroughly mix the antioxidant and oil. The bottles were then placed in an incubator at 60 °C for 15 d to induce accelerated oxidation. 2 ml aliquots were taken from each bottle every 3 days. The samples were analyzed for the PV, TBARS, CD and FFA to determine the effects of different types of antioxidants on the oxidation stability of tara seed oil [24, 25].
Statistical analyses (ANOVA) were performed using SPSS11.5 (Company name, City, Country). The results are expressed as the mean standard deviation. Results with P < 0.05 were considered significant. Each group experiment was repeated three times, and take the results were averaged results as the final experimental data.
Results and discussion
Effect of CA on the PV
The PV for each tara seed oil increased as the length of storage increased, which resulted in production of more primary oxidation products (e.g. hydroperoxides). For the experimental control group without any antioxidant, the PV increased faster and reached a higher value (163.1 ± 0.35 meq/kg) than the samples with antioxidants. Addition of one of the antioxidants (CA20, CA60, CA99, BHA, BHT, or TBHQ) decreased the PV. The PVs for CA20, CA60, CA99, BHA, BHT, and TBHQ were 90.1 ± 0.61 meq/kg, 81.4 ± 0.42 meq/kg, 62.0 ± 0.31 meq/kg, 136.5 ± 0.55 meq/kg, 101.3 ± 0.46 meq/kg, and (44.6 ± 0.49) meq/kg, respectively. Compared with the control group, the PV inhibition rates of the antioxidants CA20, CA60, CA99, BHA, BHT, and TBHQ were 44.8, 50.1, 62.0, 16.3, 37.9, and 72.7%.
These results show that CA effectively inhibited oxidation of tara seed oil, and was a stronger antioxidant than BHA and BHT but a weaker antioxidant than TBHQ. The antioxidants could be arranged in order of antioxidant strength as follows: TBHQ > CA99 > CA60 > CA20 > BHA > BHT.
Effect of CA on TBARS
Lipid oxidation generates primary oxidation products, which reduce the stability of the product and can result in further oxidation and decomposition. Further oxidation generates secondary oxidation products, such as ketones, aldehydes, and acids. Among these secondary oxidation products is MDA, which can be detected by measuring the absorbance at 532 nm MDA can be generated during oil oxidation, and can be used as an indicator of rancidity.
Compared with the control group without antioxidant (TBARS = 0.26e of 1 meq/kg), all the antioxidants reduced the TBARS. The TBARS results for CA20, CA60, CA99, BHA, BHT, and TBHQ were 0.14 ± 0.004 meq/kg, 0.122 ± 0.005 meq/kg, 0.098 ± 0.003 meq/kg, 0.193 ± 0.006 meq/kg, 0.178 ± 0.005 meq/kg, and 0.069 ± 0.001 meq/kg, respectively. The TBARS inhibition rates for CA20, CA60, CA99, BHA, BHT, and TBHQ were 46.2, 53.1, 62.3, 25.8, 31.5, and 73.5%, respectively.
These results show that CA is an effective antioxidant for reducing oxidation of tara seed oil. Compared with the other antioxidants, CA was stronger than BHA and BHT but weaker than TBHQ. The antioxidants could be arranged in order of antioxidant strength as follows: TBHQ > CA99 > CA60 > CA20 > BHA > BHT.
Effect of CA on CD
The CD content is frequently used as an indicator of hydroperoxide content, as proposed by Lecomte J et al. Most hydroperoxides formed through oxidation of unsaturated fatty acids are conjugated dienes. Formation of hydroperoxides stabilizes the radical state through formation of the double bond, which absorbs in the UV region (235 nm). The CD content is an indicator of the oxidative state of an oil, and of the effectiveness of an antioxidant.
Compared with the control group, all the antioxidants improved the stability of tara seed oil to oxidation. The control group had a CD value of 26.1 ± 0.02 at 15 days. The CD values at 15 days for the samples with CA20, CA60, CA99, BHA, BHT, and TBHQ were 18.3 ± 0.01, 14.7 ± 0.005, 12.4 ± 0.021, 24.7 ± 0.015, 21.6 ± 0.02, and 10.9 ± 0.017, respectively. The inhibition rates for CD content for CA20, CA60, CA99, BHA, BHT, and TBHQ were 29.9, 43.7, 52.5, 5.4, 17.2, and 58.2%, respectively.
These results show that CA is a good antioxidant for tara seed oil. Compared with the other antioxidants, CA is stronger than BHA and BHT, and weaker than TBHQ. The antioxidants could be arranged in order of antioxidant strength as follows: TBHQ > CA99 > CA60 > CA20 > BHA > BHT.
Effect of CA on FFA
Temperature, light, and other factors can cause oil oxidation, which generates both primary and secondary oxidation products. During oil degradation, triglyceride hydrolysis, which forms FFAs, and fatty acid dissociation occur. The FFA content can be used to determine the degree of oil oxidation.
Compared with the control group without antioxidant (15-day FFA = 0.62 ± 0.04%), all of the antioxidants decreased the FFA content. For CA20, CA60, CA99, BHA, BHT, and TBHQ the 15-day FFA results were 0.39 ± 0.04%, 0.35 ± 0.354%, 0.28 ± 0.284%, 0.22 ± 0.224%, 0.46 ± 0.464%, and 0.175 ± 0.05%, respectively. The FFA inhibition rates of CA20, CA60, CA99, BHA, BHT, and TBHQ were 37.1, 44.0, 55.0, 65.0, 26.0, and 72.0%, respectively.
These results show that CA is a good antioxidant for tara seed oil. Compared with the other antioxidants, CA is stronger than BHA and BHT, and weaker than TBHQ. The antioxidants can be arranged in order of antioxidant strength as follows: TBHQ > CA99 > CA60 > CA20 > BHA > BHT.
The antioxidant strength of CA was compared with synthetic antioxidants by adding CA20, CA60, CA99, BHA, BHT, and TBHQ to tara seed oil and exposing the samples to accelerated oxidation conditions. Analysis of oxidation indicators, including PV, TBARS, CD content, and FFA content, was used to determine the effect of each antioxidant. The results on the last day of accelerated oxidation (day 15) were compared, and showed that CA was a stronger antioxidant than the synthetic antioxidants. In order of antioxidant strength, the antioxidants were TBHQ > CA99 > CA60 > CA20 > BHA > BHT. Therefore, CA could be used to replace synthetic antioxidants, and will likely be safer for human consumption and the environment because of its lower toxicity.
ZL, LY contributed equally to performing the research, analyzing the data, and writing the manuscript. FY and YZ approved the final manuscript. All authors read and approved the final manuscript.
This work was supported by the Forestry Industry Research Special Funds for Public Welfare Projects of China (Grant No. 201404616).
The authors declare that they have no competing interests.
Consent for publication
All authors consent to the publication.
Ethics approval and consent to participate
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Open AccessThis article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.
- Skowyra M, Falguera V, Gallego G, Peiró S, Almajano MP (2014) Antioxidant properties of aqueous and ethanolic extracts of tara (Caesalpinia spinosa) pods in vitro and in model food emulsions. J Sci Food Agric 94(5):911–918View ArticleGoogle Scholar
- Li ZJ, Zhang L, ZU YG, Yang FJ (2015) Tara oil extraction by supercritical carbon dioxide and its quality analysis. Bull Bot Res 35(3):467–470Google Scholar
- Reddy LH, Couvreur P (2009) Squalene: a natural triterpene for use in disease management and therapy. Adv Drug Deliv Rev 61:1412–1426View ArticleGoogle Scholar
- Shiota M, Konishi H, Tatsumi K (1999) Oxidative stability of fish oil blended with butter. J Dairy Sci 82:1877–1881View ArticleGoogle Scholar
- Laguerre M, Lecomte J, Villeneuve P (2007) Evaluation of the ability of antioxidants to counteract lipid oxidation: existing methods, new trends and challenges. Prog Lipid Res 46:244–282View ArticleGoogle Scholar
- Zutaa PC, Simpsona BK, Zhao X (2007) The effect of α-tocopherol on the oxidation of mackerel. Food Chem 100(2):800–807View ArticleGoogle Scholar
- Trevisan M, Browne R, Ram M et al (2001) Correlates of markers of oxidative status in the general population. Am J Epidemiol 154:348–356View ArticleGoogle Scholar
- Frutos M, Hernandez-Herrero JA (2005) Effects of rosemary extract (Rosmarinus officinalis) on the stability of bread with an oil, garlic and parsley dressing. LWT 38:651–655View ArticleGoogle Scholar
- Gharby S, Harhar H, Guillaume D, Haddad A, Matthaus B, Charrouf Z (2011) Oxidative stability of edible argan oil: a two-year study. LWT Food Sci Technol 44:1–8View ArticleGoogle Scholar
- Balasundram N, Sundram K, Saman S (2006) Phenolic compound in plants and agri-industrial by-products: antioxidant activity, occurrence, and potential uses. Food Chem 99:191–203View ArticleGoogle Scholar
- Chen XQ, Zhang Y, Zu YG, Yang L, Qi L, Wang W (2014) Antioxidant effects of rosemary extracts on sunflower oil compared with synthetic antioxidants. Food Sci Technol 9:385–391Google Scholar
- Wang H, Yang L, Zu YG, Liu F, Liu TT (2011) Comparative effect of carnosic acid, BHT and α-tocopherol on the stability of squalene under heating and UV irradiation. Food Res Int 44:2730–2734View ArticleGoogle Scholar
- Wang H, Liu F, Yang L, Zu YG, Wang H, Qu SZ, Zhang Y (2011) Oxidative stability of fish oil supplemented with carnosic acid compared with synthetic antioxidants during long-term storage. Food Chem 128:93–99View ArticleGoogle Scholar
- Frankel EN, Huang SW, Prior E, Aeschbach R (1996) Evaluation of antioxidant activity of rosemary extracts, carnosol and carnosic acid in bulk vegetable oils and fish oil and their emulsions. J Sci Food Agric 72:201–208View ArticleGoogle Scholar
- Salariya AM, Rehman Z (2006) Effect of synthetic antioxidants on storage stability of Khoa—a semi-solid concentrated milk product. Food Chem 96:122–125View ArticleGoogle Scholar
- Wang L, Yang B, Yan B, Yao X (2012) Supercritical fluid extraction of astaxanthin from Haematococcus pluvialis and its antioxidant potential in sunflower oil. Innov Food Sci Emerg Technol 13:120–127View ArticleGoogle Scholar
- Hras AR, Hadolin M, Knez Z, Bauman D (2000) Comparison of antioxidative and synergistic effects of rosemary extract with a-tocopherol, ascorbylpalmitate and citric acid in sun flower oil. Food Chem 71:229–233View ArticleGoogle Scholar
- Iqbal S, Bhanger MI (2007) Stabilization of sunflower oil by garlic extract during accelerated storage. Food Chem 100(1):246–254View ArticleGoogle Scholar
- Chen XQ, Zhang Y, Zu YG (2014) Antioxidant effects of rosemary extracts on sunflower oil compared with synthetic antioxidants. Int J Food Sci Technol 49:385View ArticleGoogle Scholar
- Goli AH, Barzegar M, Sahari MA (2005) Antioxidant activity and total phenolic compounds of pistachio (Pistachia vera) hull extracts. Food Chem 92:521–525View ArticleGoogle Scholar
- Nissen LR, Mansson L, Bertelsen G, Huynh-Ba T, Skibsted LH (2000) Protection of dehydrated chicken meat by natural antioxidants as evaluated by electron spin resonance spectrometry. Journal of Agricultural and Food Chemistry 48:5548–5556View ArticleGoogle Scholar
- Duh PD, Yen GC (1997) Antioxidant efficacy of methanolic extracts of peanut hulls in soybean and peanut oils. J Am Oil Chem Soc 74:745–748View ArticleGoogle Scholar
- GB 2760–2007 (2007) Hygienic standards of uses of food additives. ChinaGoogle Scholar
- Bubonja-Sonje M, Giacometti J, Abram M (2011) Antioxidant and antilisterial activity of olive oil, cocoa and rosemary extract polyphenols. Food Chem 127:1821–1827View ArticleGoogle Scholar
- A.O.A.C. (1990) Official methods of analysis, 15th edn. Association of Official Analytical Chemists, WashingtonGoogle Scholar
- Zhang Y, Yang L, Zu YG, Chen XQ, Wang FJ, Liu F (2010) Oxidative stability of sunflower oil supplemented with carnosic acid compared with synthetic antioxidants during accelerated storage. Food Chem 118:656–662View ArticleGoogle Scholar
- Mlakarl A, Spiteller G (1996) Previously unknown aldehydic lipid peroxidation compounds of arachidonic acid. Chem Phys Lipid 79:47–53View ArticleGoogle Scholar
- Shahidi F, Wanasundara UN (1998) Methods of measuring oxidative rancidity in fats and oils. In: Akoh CC, Min DB (eds) Food lipids, chemistry, nutrition, and biotechnology. CRC Press, Boca Raton, pp 377–396Google Scholar
- Nogala-Kalucka M, Korczak J, Dratwia M, Lampart-Szczapa E, Siger A, Buchowski M (2005) Changes in antioxidant activity and free radical scavenging potential of rosemary extract and tocopherols in isolated rapeseed oil triacylglycerols during accelerated tests. Food Chem 93:227–235View ArticleGoogle Scholar